HYDROXYLATION OF NIO FILMS - THE EFFECT OF WATER AND ION-BOMBARDMENT DURING THE OXIDATION OF NICKEL FOILS WITH O-2 UNDER VACUUM

The effect of water on the oxidation of nickel surfaces under vacuum w as investigated using X-ray photoelectron spectroscopy (XPS), secondar y ion mass spectrometry (SIMS) and temperature-programmed desorption ( TPD). It was found that the presence of a small amount of water in the gas phase (of H2O partial pressures as low as 10(-8) mbar) is enough to create a monolayer or surface hydroxyl groups on top of nickel oxid e films. The formation of the OH groups was detected by both XPS and S IMS, and their superficial nature was assessed by angle-resolved XPS a nd depth profiling experiments. It was also round that the simultaneou s ion bombardment, of the surface during combined O-2 + H2O treatments leads to an enhancement in the rate growth for thr NiO film but does nor affect the formation of the OH later in any way other than via spu ttering of the surface. The most interesting observation from this wor k is the fact that adsorbed water appears to induce the reduction of n ickel oxides, as it becomes apparent by the thinning of the grown NiO films. Two temperature extremes were observed in relation to this phen omena. On the one end, exposure of nickel substrates to a combination of oxygen, argon ions and water below 200 K results in a decrease in N iO film thickness bq about a factor of two a behavior likely to be ass ociated with the enhancement in water adsorption at those at temperatu res. At the other extreme, temperatures above 650 K are also sufficien t to trigger the NiO film thinning, in this case even in the absence o f argon ions. Two possible explanations for these observations are dis cussed. (C) 1998 Elsevier Science B.V.