The effect of available chlorine concentration on the disinfecting potential of acidic electrolyzed water for shredded vegetables

The main factor contributing to the disinfecting potential of acidic electr olyzed water (AcEW) is deduced to be the oxidizing power of available chlor ine. In this study, we compared the reliability of two different methods fo r measuring the available chlorine concentration (ACC). Several AcEW soluti ons with different levels of ACC to which various reducing agents (ascorbic acid, ammonium iron (II) sulfate, and iron (II) chloride) had been added w ere prepared. These ACC levels were quantified by iodometry and the DPD (N, N-diethyl-p-phenylenediamine) method. In the case of AcEW with iron (II) i ons, iodometry did not show the correct ACC. On the other hand, the DPD met hod correctly quantified ACC even in the case of AcEW with iron (II) ions. Thus, the DPD method is an appropriate method for measuring ACC in AcEW. Moreover, we investigated the effect of the available chlorine concentratio n (ACC) in AcEW on its disinfecting potential. First, we examined the disin fectant effects of AcEW on shredded vegetables. We found that there was no difference in the disinfectant effects between AcEW with high ACC (40 ppm) and low ACC (0.4 ppm). The similar effect was detected in AcEW with 0 ppm o f ACC, a solution that seemed to be the same as hydrochloric acid. Moreover , tap water with pH adjusted to 2.4 showed the same disinfectant effect as that of AcEW. These results indicated that AcEW is a solution in which avai lable chlorine is activated in a low pH condition. Next, we examined the di sinfectant effects of AcEW on a suspension obtained from shredded vegetable s in vitro. The disinfecting potential became weaker, but did not completel y disappear, when ACC was reduced to 0 ppm, Thus, AcEW with low ACC could b e used to disinfect shredded vegetables, although the disinfecting potentia l of AcEW would become weak. When the effective concentration of Acc was examined, it was found that the AcEW with ACC of less than 20 ppm did not have sufficient disinfectant pot ential. Moreover, it was found that high ORP (above 1000 mV) does not contr ibute to disinfecting potential. Thus, the lower limit of ACC in AcEW for A cEW to exert a sufficient disinfectant effect will be 20 ppm.